Removal of Remazol Yellow from Textile Industry Wastewater by Quaternary Ammonium Polymer

Penulis

  • Agsa Ardelia Musnamar Department of Chemical Engineering Department, Faculty of Industrial Technology, Universitas Ahmad Dahlan, Indonesia
  • Aster Rahayu Department of Chemical Engineering Department, Faculty of Industrial Technology, Universitas Ahmad Dahlan, Indonesia
  • Dhias Cahya Hakika Department of Chemical Engineering Department, Faculty of Industrial Technology, Universitas Ahmad Dahlan, Indonesia
  • Nafira Alfi Zaini Amrillah Department of Chemical Engineering Department, Faculty of Industrial Technology, Universitas Ahmad Dahlan, Indonesia
  • Hutri Puspita Sari Department of Chemical Engineering Department, Faculty of Industrial Technology, Universitas Ahmad Dahlan, Indonesia
  • Syahrani Pramia Lestari Department of Chemical Engineering Department, Faculty of Industrial Technology, Universitas Ahmad Dahlan, Indonesia
  • Wah Lim Lee Department of Chemistry and Biomolecular Science, Gifu University, Japan

DOI:

https://doi.org/10.21111/atj.v9i2.14951

Kata Kunci:

Adsorption, Polymer, Quaternary Ammonium, Remazol, Waste Industrial

Abstrak

The use of Remazol Yellow dyes in the textile industry will produce waste that is mutagenic and carcinogenic. The stable nature of remazol causes Remazol Yellow to not be easily degraded photolytically or chemically. If the waste is directly disposed of into water bodies, it will accumulate and last for a long time. Adsorption is one of the textile waste processing methods that is widely used because it is an effective textile waste processing method for degrading dyes, does not require large costs, the adsorbent can be used several times, and the process is simple. This research seeks to establish the appropriate contact duration, temperature, and ideal adsorption concentration of quaternary ammonium polymers within a Remazol Yellow dye solution. The process of dye adsorption by varying the time (10; 20; 30; 40; 50; and 60) minutes, temperature (25, 30, 40, 50, 60, and 70)°C, and initial concentration (10, 20, 30, 40 and 50) ppm. The adsorption of the filtrate was then measured using a UV-Vis Spectrophotometer instrument. The dye in the Remazol Yellow solution was successfully adsorbed by the quaternary ammonium polymer with optimum conditions at 20 minutes, a temperature of 25°C, and an initial concentration of 10 ppm. The optimum adsorption percentages obtained were 98.44%, 98.54%, and 98.25% respectively. From these results, quaternary ammonium polymers can be further applied for dye degradation. Morphological analysis was carried out using a Scanning Electron Microscope (SEM) instrument, obtaining a distribution of polymer pore values after adsorption in the range of 0.84-2.09 µm. The quaternary ammonium polymer structure is in the form of a solid lump after undergoing adsorption of Remazol Yellow.   Keywords: Adsorption; Polymer; Quaternary Ammonium; Remazol; Waste Industrial

Referensi

Abdi, Z.A. M., Ambarita, H., Sitorus, T. B., Napitupulu, F. H., & P, A. (2018). Pengujian Kemampuan Adsorpsi dari Adsorben Alumina Aktif Untuk Mesin Pendingin Tenaga Surya. Jurnal Dinamis, 6(1), 57–70. https://doi.org/10.32734/dinamis.v6i1.7095

Adawiah, S. R., Sutarno, S., & Suyanta, S. (2020). Studi Adsorpsi-Desorpsi Anion Fosfat Pada Bentonit Termodifikasi CTAB. Indo. J. Chem. Res., 8(2), 125–136. https://doi.org/10.30598/ijcr.2020.8-sra

Agusdin., & Setiorini, I. A. (2020). Analisa Kemampuan Penyerapan Bubur Kertas (Pulp) dari Kertas Bekas Sebagai Adsorbent Zat Warna Reaktif dan Logam Berat (Cu dan Fe) dari Limbah Cair Tekstil dengan Adsorber Vertikal. Jurnal Teknik Patra Akademika, 11(01). https://doi.org/10.52506/jtpa.v11i01.100

Aini, N., Mufandi, I., Jamilatun, S., & Rahayu, A. (2023). Exploring Cacao Husk Waste – Surface Modification, Characterization, and its Potential for Removing Phosphate and Nitrate Ions. Journal of Ecological Engineering, 24(12), 282–292. https://doi.org/10.12911/22998993/174003

Aini, N., Rahayu, A., Jamilatun, S., & Mufandi, I. (2024). A Case Study on Functional Polymer Modification of Cacao Husk for Enhanced Removal of Nitrate and Phosphate from Vinasse Waste. Case Studies in Chemical and Environmental Engineering, 10, 1-9. https://doi.org/10.1016/j.cscee.2024.100814

Alamsyah. (2018). Kerajinan Batik dan Pewarnaan Alami. Endogami: Jurnal Ilmiah Kajian Antropologi, 136–148. https://doi.org/10.14710/endogami.1.2.136-148

Amrillah, N. A. Z., Rahayu, A., Hakika, D. C., Sisca, V., Veranica, Chusna, F. M. A., Anggresani, L., Lim, L.W. (2025). Isothermic Adsorption Study of Nitrate Ion Adsorption in Bioethanol Waste Using Quaternary Ammonium Polymer. Jurnal Sains Natural, 6(1), 1-9. https://doi.org/10.31938/jsn.v%2015i1.770

Cristina P, M., S, M. nisatun, Saptaaji, R., & Marjanto, D. (2007). Studi Pendahuluan Mengenai Degradasi Zat Warna Azo (Metil Orange) dalam Pelarut Air Menggunakan Mesin Berkas Elektron 350 Kev/10 MA. Jurnal Forum Nuklir, 1(1), 31.

Darmawan, M. I., Ilmannafian, A.G., Kiptiah, M., Husna, K. (2024). Analisis Kualitas Hasil Pemurnian Minyak Jelantah dengan Komposisi Bioadsorben Limbah Fiber Kelapa Sawit dan Bleaching Earth. Agroindustrial Technology Journal, 8(2), 68-81. http://doi.org/10.21111/atj.v8i2.12435

Elhalwagy, M. E., Elsherbiny, A. S., & Gemeay, A. H. (2023). Amine-rich polymers for water purification applications. Materials Today Chemistry, 27. https://doi.org/10.1016/j.mtchem.2022.101344

Fitriani, N.I., Puspitasari, A. R & Amelia, R. N. (2019). Dekolorisasi Senyawa Azo Limbah Remazol Golden Yellow Oleh Bioadsorben Eceng Gondok (Eichhornia crassipes). Walisongo Journal of Chemistry, 2(2), 40–46. https://doi.org/10.21580/wjc.v2i2.6023

Hayu, L. D. R., Nasra, E., Azhar, M., & Etika, S. B. (2021). Adsorpsi Zat Warna Methylene Blue Menggunakan Karbon Aktif dari Kulit Durian (Durio zibethinus Murr). Chemistry Journal of Universitas Negeri Padang, 10(2), 8–13.

Hakim, L., Rahayu, A., Jamilatun, S. (2025). Effectiveness of Ammonium Polymer in Improving Floating Treatment Wetland to Reduce Cod of Palm Oil Mill Effluent. Jurnal Sains Natural, 15, 10-18. https://doi.org/10.31938/jsn.v 15i1.768

Ifa, L., Nurdjannah, Syarif, T., & Darnengsih. (2021). Bioadsorben dan Aplikasinya. Sumatera Barat : Yayasan Pendidikan Cendekia Muslim.

Joseph, T. M., Hasanin, M. S., Unni, A. B., Mahapatra, D. K., Haponiuk, J., & Thomas, S. (2023). Macromolecules : Contemporary Futurist Thoughts on Progressive Journey. Eng, 4, 678–702. https://doi.org/10.3390/eng4010041

Maghfiroh, L., Ulfin, I., & Juwono, H. (2016). Pengaruh pH terhadap Penurunan Zat Warna Remazol Yellow FG oleh Adsorben Selulosa Bakterial Nata De Coco. Jurnal Sains Dan Seni ITS, 5(2), 2337–3520. https://doi.org/10.12962/j23373520.v5i2.17719

Maihendra, Fadli, A., & Zultiniar. (2016). Kinetika Adsorpsi pada Penjerapan Ion Timbal Pb2+ Terlarut dalam Air Menggunakan Partikel Tricalcium Phosphate. Jom FTEKNIK Volume, 3(2), 1–5. https://jom.unri.ac.id/index.php/JOMFTEKNIK/article/view/11480/11128

Musnamar, A. A., Rahayu, A., Hakika, D.C. (2024). Pengaruh Variasi Massa Terhadap Penyerapan Remazol Kuning Dengan Polimer Ammonium Kuartener. Prosiding. Seminar Nasional Inovasi dan Teknologi (SEMNASINTEK). Universitas Ahmad Dahlan. Yogyakarta, 27 November 2024. https://seminar.uad.ac.id/index.php/SNIT/article/view/19081/5848

Mustapa, & Zulfikar, M. A. (2023). Polimer Bercetakan Molekul sebagai Adsorben Zat Warna Metilen Biru. Fullerene Journ.Of Chem, 8(1), 1–5. https://doi.org/10.37033/fjc.v8i1.497

Rahayu, A., Hakika, D. C., Amrillah, N. A. Z, & Veranica. (2023). Synthesis and Characterization of Ammonium Polymer for Anion Removal in Aqueous Solutions. Polimery, 68(10). https://doi.org/10.14314/polimery.2023.10.3

Rahayu, A., Hakika, D. C., Amrillah, N. A. Z., Sisca, V., Veranica, Chusna, F.M.A., Anggresani., Lim, L.W. (2025). The Adsorption and Kinetics Studies of Nitrate Ions From Bioethanol Wastewater by Ammonium-Based Ion Exchange Polymer. Ecological Engineering & Environmental Technology, 26 (3), 54-69. https://doi.org/10.12912/27197050/199560

Rahayu, A., Jamilatun, S., Fajri, J. A., & Lim, L. W. (2021). Characterization of Organic Polymer Monolith Columns Containing Ammonium Quarternary as Initial Study for Capillary Chromatography. Elkawnie, 7(1), 119. https://dx.doi.org/10.22373/ekw.v7i1.8764

Said, M., Riyanti, F., Hariani, P. L., Sastriani, & Rizki, W. T. (2022). Removal of Remazol Yellow Using SnO2-Co Photocatalyst. Pertanika Journal of Science and Technology, 30(3), 1949–1962. DOI: https://doi.org/10.47836/pjst.30.3.10

Sari, Y. D. Y., & Damayanti, A. (2020). Penggunaan Pewarna Sintetis dan Alam Pada Lukis Kain The Use of Synthetic And Natural Colors in Fabric Painting. Garina : Jurnal Ipteks Tata Boga, Tata Rias, Dan Tata Busana, 12(2), 41–50. https://doi.org/10.69697/garina.v12i2.51

Setiawan, D. A., Sirajuddin, & Ricky Marthin De Tulus Wanwol. (2023). Adsorption of Remazol Brilliant Blue R Dye Using Activated Carbon from Emty Palm Oil Bunches. Jurnal Sains Natural, 13(4), 183–190. https://doi.org/10.31938/jsn.v13i4.527

Subagyo, P. K., & Soelityowati. (2021). Pengaruh Zat Pewarna Sintetis terhadap Pewarnaan Kain Batik. Folio, 2(2). https://doi.org/10.37715/folio.v2i2.3476

Tamirat, A. G., Sendek, A., & Libsu, S. (2014). Optimizing Dyeing Parameters of Remazol Golden Yellow G Dye upon Cotton Fabric. International Journal of Advanced Research, 2(10), 234–240. https://www.journalijar.com/article/2841/optimizing-dyeing-parameters-of-remazol-golden-yellow-g-dye-upon-cotton-fabric/

Veranica., Rahayu, A., Maryudi, Hakika, D.C., Lim, L.W., & Anggresani, L. (2024). Isotherm Adsorption of Ion Phosphate from Vinasse Waste Using Quaternary Ammonium Polymer as Adsorbent in Term Effect of Temperature. Jurnal Sains Natural, 14(2), 91–97. https://doi.org/10.31938/jsn.v14i2.720

Vianti A, F., & Yustinah. (2015). Pengaruh Temperatur pada Proses Pemurnian Minyak Goreng Bekas dengan Buah Mengkudu. Konversi, 4(4), 53–62. https://doi.org/10.24853/konversi.4.2.53-62

##submission.downloads##

Telah diserahkan

2025-08-11

Diterbitkan

2025-11-30

Cara Mengutip

Musnamar, A. A., Rahayu, A., Hakika, D. C., Amrillah, N. A. Z., Sari, H. P., Lestari, S. P., & Lee, W. L. (2025). Removal of Remazol Yellow from Textile Industry Wastewater by Quaternary Ammonium Polymer. Agroindustrial Technology Journal, 9(2), 100–107. https://doi.org/10.21111/atj.v9i2.14951

Terbitan

Vol 9 No 2 (2025): Agroindustrial Technology Journal [ATJ]

Bagian

Articles

Lisensi

Creative Commons License

Artikel ini berlisensiCreative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.

The author whose published manuscript approved the following provisions:

1. The right of publication of all material published in the journal / published in the Agroindustrial Technology Journal is held by the editorial board with the knowledge of the author (moral rights remain the author of the script).

2. The formal legal provisions for access to digital articles of this electronic journal are subject to the terms of the Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License (CC BY-NC-SA 4.0), which means that Agroindustrial Technology Journal reserves the right to save, transmit media or format, Database), maintain, and publish articles without requesting permission from the Author as long as it keeps the Author's name as the owner of Copyright.
3. Printed and electronically published manuscripts are open access for educational, research and library purposes. In addition to these objectives, the editorial board shall not be liable for violations of copyright law.