Optimasi Penggunaan Kembali Limbah Karbon Aktif Industri Vetsin Sebagai Biochar Menggunakan Taguchi Orthogonal Array L4

Optimising The Reuse Of Vetsin Industry Activated Carbon Waste As Biochar Using The Taguchi Orthogonal Array L4

Authors

  • Anggra Setiyo Irnanto Program Studi Teknik Industri, Program Pascasarjana, Institut Teknologi Nasional (ITN) Malang, Indonesia
  • Fourry Handoko Program Studi Teknik Industri, Program Pascasarjana, Institut Teknologi Nasional (ITN) Malang, Indonesia
  • Dimas Indra Laksmana Program Studi Teknik Industri, Program Pascasarjana, Institut Teknologi Nasional (ITN) Malang, Indonesia

Keywords:

Kata Kunci: Biochar, taguchi, limbah karbon aktif, reuse.

Abstract

PT XY is a company producing vetsin in the food industry. The company makes extensive use of material resources for its industrial development, which has an impact on the environment. Waste-activated carbon is the result of the color absorption process of the solution. The problem is that the waste generated causes pollution to the company's environment and cannot be stored for long. The average carbon waste generated from January to December 2023 is 86.40 tonnes. Therefore, it is necessary to reuse activated carbon waste into biochar or carbon fertilizer. Processing strategy by conducting experiments using the Taguchi method. Problem identification with an approach that refers to the Responsible Waste Management Hierarchy, and limits the implementation of experiments to the principle of reuse. The Taguchi Orthogonal Array L4 method was chosen for the experimental design because it is more cost-effective than other DOEs and the signal noise is predictable. This research was conducted through experimental methods to know the effect of biochar planting media from activated carbon waste on the growth of kale plants (gr) and get optimal composition variations. As a result, an optimization design was obtained with wet carbon waste material, 25% biochar concentration, and bright light conditions, with an n-gain value of 4.49 resulting in a high improvement category. Comparison of biochar quality with Charcoal Powder from Workplant Store by SNI 06-3730-1995 standard. In biochar products from activated carbon waste, there is a glutamate content of 0.345 g/dL which is a good amino acid for plant growth.

References

Ardyansah Ryan, et al. 2017. Studi Pemanfaatan Limbah Karbon Aktif sebagai Bahan Pengganti Agregat Halus pada Campuran Beton Ringan (Studi Kasus di PT PETRONIKA). Politeknik Perkapalan Negeri Surabaya: Jurusan Teknik Permesinan Kapal. Proceeding 1st Conference on Safety Engineering and Its Application, ISSN No. 2581 – 1770.

BPOM RI. 2022. List Of Food Additives (E-Registration Application). Accessed on February 18, 2024 at 22.30, from https://ereg-rba.pom.go.id/front/informasibtp.

Bagchi. 2013. Taguchi Methods Explained Practical Steps to Robust Degin. New Delhi: Published by Prentice – Hall of India Private Limited, M-97, Connaught Circus, and Printed by Bhuvnesh Seth at Rajkamal Electric Press, B-35/9, G.T. Karnal Road Industrial Area, Delhi110033

Firdaus R S . 2023. Optimasi Formulasi Karet Alam Sebagai Material Kaki Palsu Menggunakan Metode Taguchi Orthogonal Array L4. Universitas Islam Indonesia : Fakultas Teknologi Industri. Tugas Akhir.

Herlambang, et al . 2020. Salah Satu Alternatif Untuk Perbaikan Lahan Dan Lingkungan. UPN “Veteran” : Buku Ajar Biochar. https://www.spssindonesia.com/2014/01/uji-normalitas-kolmogorov-smirnov-spss.html

Setiawan Adi, et al. 2021. Sintesis Karbon Aktif Limbah Lumpur Aktif Industri Gula sebagai Adsorben Limbah Logam Berat Cu (II). Politeknik Perkapalan Negeri Surabaya (PPNS): Program Studi Teknik Pengolahan Limbah, doi: 10.14710/teknik. v42i3.36031,

Lubis Riska AF, et al. 2020. Production of Activated Carbon from Natural Sources for Water Purification. Universitas Negeri Medan: Jurusan Kimia. Indonesian Journal of Chemical Science and Technology (IJCST-UNIMED) (2020) Volume 03, No 2 , pp 67-73

Nekere et al. 2012. Optimization of Aluminium Blank Sand Casting Process By Using Taguchi’s Robust Design Method. International Journal for Quality research.

Muharrom and Siswadi. 2015. Taguchi's experimental design to improve the quality of clay-based bricks. Jemis Vol. 3 No. 1 of 2015.

Liu, X., Yuekuan, Z., Chun Qing, L., Yaolin, L., Wei, Y., Guoqiang, Z. 2019. Optimization of a new phase change material integrated photovoltaic/thermal panel with the active cooling technique using Taguchi method. Energies 12(6): 1±22.

Downloads

Published

2024-12-25

How to Cite

Setiyo Irnanto, A., Fourry Handoko, & Laksmana, D. I. . (2024). Optimasi Penggunaan Kembali Limbah Karbon Aktif Industri Vetsin Sebagai Biochar Menggunakan Taguchi Orthogonal Array L4: Optimising The Reuse Of Vetsin Industry Activated Carbon Waste As Biochar Using The Taguchi Orthogonal Array L4. Gontor Agrotech Science Journal, 10(2), 146–156. Retrieved from https://ejournal.unida.gontor.ac.id/index.php/agrotech/article/view/12585

Issue

Vol. 10 No. 2 (2024): December 2024 (In Progress)

Section

Articles

License

The author whose published manuscript approved the following provisions:

    1. The right of publication of all material published in the journal / published in the Gontor AGROTECH Science Journal is held by the editorial board with the knowledge of the author (moral rights remain the author of the script).
     2. The formal legal provisions for access to digital articles of this electronic journal are subject to the terms of the Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License (CC BY-NC-SA 4.0), which means that Gontor AGROTECH Science Journal reserves the right to save, transmit media or format, Database), maintain, and publish articles without requesting permission from the Author as long as it keeps the Author's name as the owner of Copyright.
     3. Printed and electronic published manuscripts are open access for educational, research and library purposes. In addition to these objectives, the editorial board shall not be liable for violations of copyright law.